|本期目录/Table of Contents|

[1]王 平,张岳明,陆向军,等.基于电梯钢丝绳磨损与张力偏差的研究[J].工业仪表与自动化装置,2019,(02):61-62.[doi:1000-0682（2019）01-0000-00]
　WANG Ping,ZHANG Yueming,LU Xiangjun,et al.Research on wear and tension deviation of elevator wire rope[J].Industrial Instrumentation & Automation,2019,(02):61-62.[doi:1000-0682（2019）01-0000-00]
点击复制

基于电梯钢丝绳磨损与张力偏差的研究

《工业仪表与自动化装置》[ISSN:1000-0682/CN:61-1121/TH]

卷:
期数:
2019年02期
页码:
61-62
栏目:
出版日期:
2019-04-15

文章信息/Info

Title:
Research on wear and tension deviation of elevator wire rope
作者:
王 平1; 张岳明1; 陆向军1; 陈启东2
1.江苏省特种设备安全监督检验研究院常熟分院；
2.常熟理工学院 机械工程学院，江苏 常熟215500
Author(s):
WANG Ping1;  ZHANG Yueming1;  LU Xiangjun1;  CHEN Qidong; 2
1.Changshu Branch of Jiangsu Special Equipment Safety Supervision and Inspection Institute;
2.School of Mechanical Engineering, Changshu Institute of Technology, Jiangsu Changshu 215500,China
关键词:
电梯; 钢丝绳磨损; 张力偏差; 振动频率
Keywords:
elevator;  wire rope wear;  tension deviation;  vibration frequency
分类号:
TH113.1
DOI:
1000-0682（2019）01-0000-00
文献标志码:
A
摘要:
由于电梯的频繁使用以及安装误差使得钢丝绳的磨损不均，进而导致各股钢丝绳张力之间存在一定的偏差。该文对钢丝绳磨损与张力偏差之间的关系进行了研究，并通过动态采集钢丝绳在磨损后的振动频率计算出动态状态下的张力。现场试验验证方法的可行性，从而有效地反映出钢丝绳磨损量与张力之间的函数关系。
Abstract:
Because of the frequent use of elevators and installation errors, the wire rope wear is not uniform, which leads to a certain deviation between the tension of each wire rope.The relationship between the abrasion of wire rope and the deviation of tension is studied in this paper.The feasibility of the method is verified by field test, which can reflect the function relation between the amount of wear and tension of wire rope effectively.

参考文献/References:

[1] 朱玉堂,田志勇,戴一平.钢丝绳断丝损伤定量检测技术[J].机电工程,2008,25(08):44-46.

[2] 田志勇,张耀,谭继文.基于BP神经网络的钢丝绳断丝定量检测[J].煤炭学报,2006,31(2):245-249.
[3] 刘云楷,徐桂云,张晓光.多绳摩擦式提升机钢丝绳张力在线监测系统[J].煤矿机械,2011,32(05):131-133.
[4] 陆延红,华钢,陈凤军,等.基于最小二乘法的钢丝绳断丝定量检测技术的研究[J].矿山机械,2010,38(01):55-59.
[5] SUMYONG,PRATEEPASEN A,KAEWTRAKUL PONG P.Influence of scanning velocity and gap distance on magnetic flux leakage measure[J].ECTI Transactions on Electrical Eng,Electronics and Communication, 2007, 5(1): 118-122.
[6] JOMDECHAC, PRATEEPASEN A, METHONG W. Characterization of wire rope defects from magnetic flux leakage signals[J].Thammasat International Journal of Science and Technology,2003,8(1):54-63.
[7] 陈厚桂,康宜华,武新军.基于相关性的钢丝绳断丝特征提取[J].机械工程学报,2006,42(5):224-228.
[8] 张俊杰,文学洙.一种提升机钢丝绳张力动态测量装置的设计与分析[J].机械制造,2015,53(11):80-82.

相似文献/References:

[1]王建邦,王 飞,郭晓斌,等.基于STM32的电梯智能按键装置的设计与应用[J].工业仪表与自动化装置,2019,(02):53.[doi:1000-0682(2019)02-0000-00]
　WANG Jianbang,WANG Fei,GUO Xiaobin,et al.Design and application of elevator intelligent button device based on STM32[J].Industrial Instrumentation & Automation,2019,(02):53.[doi:1000-0682(2019)02-0000-00]
[2]王 平,陆向军,张岳明.基于模态分析的电梯平衡系数空载测量法研究[J].工业仪表与自动化装置,2020,(02):81.
　WANG Ping,LU Xiangjun,ZHANG Yueming.Research on no-load measurement of elevator balance coefficient based on modal analysis[J].Industrial Instrumentation & Automation,2020,(02):81.
[3]林生富.声控无线电梯制动距离测量系统开发[J].工业仪表与自动化装置,2020,(06):56.[doi:1000-0682(2020)06-0000-00]
　LIN Shengfu.Development of braking distance measurement system for elevator based on sound-control and wireless[J].Industrial Instrumentation & Automation,2020,(02):56.[doi:1000-0682(2020)06-0000-00]

备注/Memo

备注/Memo:
收稿日期：2018-09-10
基金项目：江苏省特种设备安全监督检验研究院项目(KJBS2016-1)
作者简介：王平，男，江苏省特种设备安全监督检验研究院常熟分院副院长，
更新日期/Last Update: 2019-01-15